cement rotary kiln waste gases

Potential savings in the cement industry using waste heat recovery ...

2023.9.15 The waste heat source was a gaseous effluent from a cement rotary kiln. The ORC presented the best exergo-economic performance, the highest net power output and the lowest total capital cost. For the case of TLC, it is found that the exergetic

Evaluation of waste heat recovery technologies for the

2020.11.1 In this work, the waste heat obtained from the cooling of a high-temperature gas effluent from the rotary kiln in a Colombian is analysed for its potential

The generation of power from a cement kiln waste gases:

2017.4.1 The generation of Power from the cement kiln Waste Heat gases is an energy saving opportunity and it entails the recovery of the

Utilization of cement rotary kiln waste heat for calcination of ...

2020.12.1 In cement plants, high temperature heat is released into the atmosphere through exhaust flue gases, radiation and convection heat from hot

Waste heat recovery and utilization of cement rotary kiln based on ...

Waste heat recovery and utilization of cement rotary kiln based on biomass energy Liu, E., Jiang, Y., Guo, Z., Qian, Y., Yan, R., Wang, Y., and Wang, S. (2023). “ Waste heat

Oxygen Monitoring of Kiln Waste Gases in the Cement Industry

gases on a wet process cement plant. Due to the evaporation of water from the slurry the temperature of the waste gases is reduced to 300 °C/400°C at the kiln feed point. It is

Energy audit and waste heat recovery from kiln hot shell surface of

2020.10.1 In this study, a cement rotary kiln is taken as centre of discussions where thermodynamics of rotary kiln, energy losses, refractory selection and their impact,

Full article: Modeling operational cement rotary kiln variables with ...

2022.10.20 In cement production, the rotary kiln is a rotating furnace tube for baking and turning the raw material into cement clinker (Sharabiany, Fatehi, and Araabi Citation

A Thermoelectric Waste-Heat-Recovery System for

2014.12.9 In this paper we propose a novel thermoelectric waste-heat-recovery system to reduce heat losses from cement rotary kilns. This system is configured as an

Modeling of the Thermochemical Conversion of Biomass

2020.3.28 8 Citations Metrics Abstract Because of the depletion of fossil fuels and because of its increasing cost, waste has been used as alternative fuels in cement